裝載機一旦柴油機出現問題，就會直接導致裝載機無法正常工作，但是對于柴油機而言，啟動困難是我們常常與到的故障，那么在遇到啟動困難時應該如何處理呢？

一、觀察柴油機的啟動轉速。當按下起動按鈕而不能啟動時，可能出現以下幾種現象：起動轉速正常；起動轉速降低；曲軸因啟動電機不工作，或起動電機空轉而不轉動。上述現象除起動轉速正常外，都屬于蓄電池或起動電路技術狀況不良造成的故障現象，故應檢查蓄電池和啟動電路技術狀況。
Observe speed diesel engine starts. When you press the start button and can not start, it may appear the following phenomenon: the normal starting speed; starting speed is reduced; crankshaft due to the starter motor is not working, or not turning the starter motor idling. In addition to the above phenomena outside normal starting speed, are all caused by poor symptom technical condition of the battery or the starter circuit, so you should check the technical condition of the battery and start circuit.
二、啟動轉速正常，但是發動機不能啟動，應注意查看柴油是否進入氣缸，即觀察排氣管是否排煙和傾聽發動機有無爆發生。若起動時無煙排出，也無爆發聲，表明柴油沒有進缸，原因是噴油泵不泵油，或低壓油路不供油?？上葯z查郵箱內是否有油，然后擰松噴油泵上的放氣螺釘，檢查油路是否堵塞和有空氣，如上述檢查正常，再進一步檢查噴油泵是否泵油。
Start speed is normal, but the engine does not start, you should pay attention to see if the diesel into the cylinder, that observe and listen to the exhaust pipe of the engine exhaust is whether the outbreak of the students. If the starter smokeless exhaust, no outbreak of sound, indicating that there is no diesel into the tank, because the fuel pump does not pump oil, or low pressure oil is not oil. Can first check whether there is oil in the mailbox, and then loosen the bleed screw on the fuel pump, check the oil and air is blocked, such as the examination is normal, check the fuel pump if the pump further oil.